Mercedes to use F1 MGU-H technology in road cars
- Published on 17 Jun 2020 13:38
-
- By: Fergal Walsh
Mercedes has announced that a new engineering development, which has been inspired by its Formula 1 division, will be implemented throughout the next AMG vehicle generation.
The German manufacturer says it has been producing an electric exhaust gas turbocharger, which is already in the final development stages.
The part has been built using the knowledge gained from the Motor Generator Unit - Heat (MGU-H) that's part of the Formula 1 Energy Recovery System.
The MGU-H, which was first introduced into F1 in 2014, has received criticism with some pointing out that it is not road relevant.
Mercedes says the “highlight” of the electric exhaust gas turbocharger is a “slim electric motor integrated onto the charger shaft, between the turbine wheel on the exhaust side and the compressor wheel on the fresh air side”.
The electric motor drives the compressor wheel before accepting exhaust gas flow. The electrification of the turbocharger greatly enhances initial response from idle speed and across the entire engine speed range, all the while eliminating turbo lag.
This means the combustion engine responds faster to input on the accelerator pedal, providing a “more dynamic driving feel” and enabling higher torque at low engine speed, improving acceleration from a standstill.
CEO of Mercedes-AMG GmbH Tobias Moers said: "We have clearly defined our goals for an electrified future. In order to reach them, we are relying on discrete and highly innovative components as well as assemblies.
"With this move we are strategically supplementing our modular technology and tailoring it to our performance requirements.
“In a first step this includes the electrified turbocharger - an example of the transfer of Formula One technology to the road, something with which we will take turbocharged combustion engines to a previously unattainable level of agility."
1
Replies (4)
Login to replycalle.itw
Posts: 8,527
If anyone should do it, it'd be them.
Snooky
Posts: 121
Imagine the repair bill if it goes wrong
xoya
Posts: 583
Cars will be driveable in warranty period only, anyhow.
Just imagine all the touch screens and touch sensitive controls after 10 years have passed.
Try using your phone from 6 years ago.
RogerF1
Posts: 501
Any of you techy’s out there might find this interesting as a closer look. Will not be used in road cars for energy recovery only to improve response. I don’t expect ‘replacement’ units to be massively more expensive considering the detuning of the system. As always the weak link in turbos is the bearings/oil seals on the centre housing, doubtful to be the motor.
www.enginetechnolo(...)rbo-technology.html